__NOTOC__
Capital maintenance expenditure is the costs cost of renewing, replacing, rehabilitating, refurbishing or restoring assets to ensure that services continue at the same level of performance that was first delivered. Examples include replacing a motor on a power pump or the pump rods/rising main/handle in a handpump; cleaning/re-excavating the base of a hand-dug well; relaying the drainage field for a septic tank; flushing a borehole which no longer delivers the desired flow; cleaning a water tank, etc. The renewal of these assets, often after some years of operation, ensures the same level of service that users received when the asset was first installed.
Planning for capital maintenance expenditure is crucial to the sustainability of water, sanitation and hygiene services as shown in figure 1. The red line shows a steady decline in service levels in the absence of capital maintenance as a system degrades over time. Eventually there is a need for renewed capital expenditure to replace the asset. The blue line shows service levels being maintained as the asset is maintained.
====Difference between operational expenditure and capital maintenance====
When an existing system undergoes minor maintenance, for example regular greasing of bearing points or tightening of pump bolts, the related cost is part of [[Operational and Minor Maintenance Expenditure (OpEx)|operational and minor maintenance expenditure (OpEx)]]. The point where minor maintenance becomes capital maintenance is a matter of frequency; ''does the cost occur more than once a year?'' and of amount; ''Is the cost significant compared to the on-going operational expenditure?'' For example, although the cost of emptying a twin pit or shallow pit-latrine may be significant compared to the initial investment needed for construction, it occurs frequently, at least compared to the life cycle of the latrine itself, and does not constitute a physical renewal. Thus, it is considered as [[Operational and Minor Maintenance Expenditure (OpEx)|operational and minor maintenance expenditure (OpEx)]]. However, the cost of emptying a single deep pit might only be needed once every five to ten years and might usefully be considered as capital maintenance expenditure. The replacement of a small valve on a piped system, or repairing a leaking pipe is [[Operational and Minor Maintenance Expenditure (OpEx)|operational and minor maintenance expenditure (OpEx)]], although its failure can significantly affect the serviceability of the system, because this is a small cost which occurs frequently compared to the life of the system. Replacing a length of pipe because there have been a number of leaks, or replacing a major valve after several years of use would be classified as capital maintenance expenditure.
==Examples==
====Benchmarks capital maintenance====
Based on research from the [[#WASHCost|WASHCost]] project, the minimum capital maintenance expenditure to provide a basic level of water service with a borehole and handpump (at 2011 prices) ranges from US$ 1.5 per person to just over US$ 2 per person (see table 1). For all piped schemes, including mechanised boreholes and piped supplies, the costs range from US$ 1.5 to just over US$ 7 per person.
'''Table 1. Cost ranges for capital maintenance expenditure [min-max] in US$ 2011 per person, per yearfor a basic level of service.'''
{|border="1" cellspacing="0" cellpadding="5"
|-
The costs as shown in table 1 (above) are based on the provision of a basic level of water service, as defined by [[#WASHCost|WASHCost]]. A basic service implies that the following criteria have been realised by the majority of the population in the service area: People access a minimum of 20 litres per person per day, of acceptable quality (judged by user perception and country standards) from an improved source which functions at least 350 days a year without a serious breakdown, spending no more than 30 minutes per day per round trip (including waiting time).
Based on research from the [[#WASHCost|WASHCost]] project, the minimum capital maintenance expenditure required to provide a basic level of sanitation service ranges from US$ 0.5 to just over US$ 1.5 per person, for a [[Single Pit|Traditional Pit]] latrine, between US$ 1 – 3 for a [[Single Ventilated Improved Pit|Ventilated Improved Pit (VIP)]] latrine and between US$ 2 – 6 (2011 prices) for pour Flush or septic tank latrines (see table 2).
'''Table 2. Cost ranges for expenditure on capital maintenance expenditure [min-max] in US$ 2011 per person, per yearfor a basic level of service.'''
{|border="1" cellspacing="0" cellpadding="5"
|-
====Financing of capital maintenance====
Mechanisms to finance long-term repairs or capital maintenance have been less clearly defined and ongoing asset management is rarely planned for in programme implementation (Fonseca et.al, 2013). [[Tariffs | Tariffs]], where used, are usually set at a level that should cover operational and minor maintenance but not the full replacement costs of assets. A fear that tariffs would be unaffordable to rural users has led to reluctance to introduce cost-reflective pricing in many low-income countries, much as in high-income countries.
==Key documents==
* Fonseca, C., Brikké, F. and Kouassi Komlan, E., 2005. Planning for Sustainable Cost Recovery in Community-Based Water Supply Services. Delft: IRC International Water and Sanitation Centre.
:This practical guide provides training on cost recovery and strategies for rural water supply.
* Fonseca C., Smits S., Nyarko K., Naafs A. and Franceys R., 2013. [http://www.washcost.info/page/2713 Financing capital maintenance of rural water supply systems: current practices and future options]. (Working Paper 9). The Hague, The Netherlands: IRC International Water and Sanitation Centre.
* Franceys, R. and Pezon, C., 2010. [http://www.washcost.info/page/866 Services are forever: the importance of capital maintenance (CapManEx) in ensuring sustainable WASH services]. (WASHCost briefing note; no. 1b). The Hague, The Netherlands: IRC International Water and Sanitation Centre.
:This 8-page briefing note introduces the concept of capital maintenance expenditure.
==Links==
<div id="WASHCost">'''WASHCost'''</div>
* WASHCost was a five-year action research programme, running from 2008 to 2012. The WASHCost team gathered information related to the costs of providing water, sanitation, and hygiene services for an entire life cycle of a service -- from implementation all the way to post-construction. The WASHCost programme was led by IRC International Water and Sanitation Centre with several partners to collect data in the rural and peri-urban areas of Burkina Faso, Ghana, India, and Mozambique. For more information see: [http://www.washcost.info WASHCost]
* The Costing Sustainable Services online course was developed to assist governments, NGOs, donors and individuals to plan and budget for sustainable and equitable WASH services, using a life cycle cost approach. The Life cycle cost approach is a methodology for costing sustainable water, sanitation and hygiene service delivery and comparing the costs to the level of service received by users. For more information see: [http://www.washcost.info/page/2448 washcost.info/page/2448]
* WASHCost data sets provide access to the validated life cycle cost and service level information collected in Burkina Faso, Ghana, Andhra Pradesh (India), and Mozambique between 2009 and 2010. The data has been collated from a number of sources including infrastructure surveys, detailed household surveys and a range of specific research undertaken with stakeholders in each country. The data sets are available at [[http://www.washcost.info/page/2716 washcost.info/page/2716]]
* Triple-S (Sustainable Services at Scale) is a six-year, multi-country learning initiative to improve water supply to the rural poor. It is led by IRC International Water and Sanitation Centre. The initiative is currently operating in Ghana and Uganda. Lessons learned from work in countries feeds up to the international level where Triple-S is promoting a re-appraisal of how development assistance to the rural water supply sector is designed and implemented. For more information see: [http://www.waterservicesthatlast.org/ Water Services That Last]
